This Ram Pump is capable of flowing water over a distance of 14,200 m. Ram Pump for Nisam People

This Ram Pump supplies water as far as 14,200 meters Channel Traditional Viewers in this edition we will be doing Ram pump maintenance, which is located in Nisam Between Aceh Province - Indonesia Now let's see the condition of the ram pump which was built 2 years ago, - is still functioning well. This is when the condition of the pump is still newly installed but it is necessary to increase the water discharge in the outlet pipe, namely by replacing a new tube with a large and wide size The old ram pump tube is 1.2 meters After 2 years of working this pump, there is not much damage, only a few parts that need repair such as Soct drat out pipe, pressure gauge and on the exhaust valve lever this is considering the age factor of this ram pump The new pump tube, with a diameter of 2.3 meters x 6 inches which we will use to replace the old tube this is a replacement for the rubber packing on the flange, overcoming the pump not leaking at the bolt connection and on the waste valve New Pump tube installation process, length 2.3 meters then the connection of the out pipe is still on using a 1.5 inch HDPE pipe connection using high quality pipe glue on the out pipe, for this maintenance edition we purposely did not use a pressure gauge After the pipe connection is complete we pay attention to the condition of the water in the input pipe, is the pressure still strong? If the water pressure in the input pipe is still strong, the pump can be reactivated immediately If the water pressure is still low it is necessary to check the outlet pipe and dam he water pressure in the input pipe is very strong good rubber packing is needed to overcome leaks in the pipe bolts and flange on the out pipe, for this maintenance edition we purposely did not use a pressure gauge It takes strong pressure for the waste valve to work usually up to 4 presses waste valve works well finished installing the pump and air tube, then we check the water that comes out of the pipe out try to open the pipe connection out the distance from the pump is 25 m the water discharge issued is very large the water pressure is also very strong if the water discharge is still small, it is necessary to adjust the pump, namely the waste valve lever setting the knock distance on the waste valve, from 8 cm to 10 cm and need locking bolts so they don't come off easily and need locking bolts so they don't come off easily Control the air holes on the out pipe for easy water distribution This out pipe (distribution pipe) measures 1.5 inches HDPE with a distribution pipe length of 14,200 meters need 10 units of air holes for smooth water distribution all the air holes are working again a very wide water reservoir, this is where the final destination of the water distributed by the Ram pump is This is the distribution pipe to the reservoir from the ram pump with a distance of up to 14,200 meters This water comes out continuously for 24 hours water discharge reaches 62 liters/minute This is a water reservoir in the Darut Thalibin Islamic Boarding School complex. with the number of students as much as 1,500 people The need for raw water for this Islamic boarding school has been met according to community expectations THANK YOU FOR ALL

Channel: Tradisional Channel

Views: 33,522

Keywords: ram pump work, pump no electricity, pompa hidram, pompa ram aceh, Incredible this ram pump, tradisional channel, traditional channel, pompa hidram terbaik, pompa hidram nisam, ram pump to bording school, ram pum maintenance, palu air pada pompa ram, rap pum international, suplai air sejauh 14.200 meter, Hydraulic Ram Pump, ram pump for student

Id: xBxvc_4tQ-8

Length: 13min 34sec (814 seconds)

Published: Sun Sep 11 2022